There are no safety recalls for the 2005 Airstream Sprinter Westfalia, but owners have filed 6 complaints with NHTSA.
2005 Airstream Sprinter Westfalia problems reported by owners
| Problem area | Reports | |
|---|
| Suspension | 2 | |
| Electrical System | 2 | |
| Wheels | 1 | |
| Equipment Adaptive/Mobility | 1 | |
| Steering | 1 | |
Most reported parts
- Wheels › Hub — 1
- Suspension › Front › Stabilizer Bar — 1
Typical mileage at the time of the problem: 1,280 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Airstream Sprinter Westfalia complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Suspension · at 950 miles · reported Apr 14, 2012
2005 airstream westfalia sprinter 2500 conversion van this vehicle is extremely unstable at highway speeds with the presence of cross winds or large trucks passing by. This problem existed from the very beginning when I purchased the van but only on windy days and/or highway speeds. I brought this to the attention of an airstream representative but did not receive any positive feedback. I cannot help but think that someday this problem is going to result in an accident. Since I had this problem for a long time, I was hesitant to drive the vehicle but now that I AM planning on retiring and…
Equipment Adaptive/Mobility · at 13,000 miles · reported Jun 25, 2009
Running boards are falling off. They are made of solid aluminum and attached to the body with #12 self-drilling sheet metal screws. One of the running boards came off when I stepped on it to go somewhere. Out of the 16 screws (8 per running board), only two were tight, and I was able to tighten two more. The remaining 12 will not tighten. Only thing I can do is epoxy them in.
Electrical System · reported Sep 20, 2006
Possible fire and electrocution hazards due to an electrical outlet. This outlet is located behind the right-rear back door. It is about one foot below the water connector plug for the outdoor shower. All the mentioned equipment was built and sold by airstream. 1. Possible fire hazard: both the electrical outlet and the cable (14/3 cable) attached to it are rated for 15 amps. (This is a two-plug outlet.) the problem is that: 1a. The 15 amp cable is spliced to a 20 amp cable (12/3 cable) somewhere within the body of the vehicle. 1b. Then the 20 amp cable runs to a 20 amp circuit breaker in the…
Electrical System · reported Jul 19, 2006
Possible root cause: use of a 13 amp circuit breaker (Too small) in a line for a part that specifies a 15 amps line. Description: intermittent but frequent tripping of the circuit breaker in the 2005 airstream (Dodge sprinter westfalia model) electrical line dedicated to sole use by the tappan microwave oven, when the oven first turns on or cycles on (When at power levels less than 10). The problem occurred on several different dates. Supply voltage was measured in the airstream on two of these dates and found to be 120 volts AC (Within specification). Tappan's written requirements specify a…
Suspension · at 1,280 miles · reported May 25, 2006
My wife and I bought a 2005 airstream westfalia 18 (Dodge sprinter-based) camper conversion van in march of this year. After getting the unit home and giving it a once-over that included inflating the tires to the recommended pressures, we left upstate ny for a trip south through pa, to washington DC and then on to nyc, returning home after putting on about 1200 miles. During the trip we noticed that the van had noticeable body roll (To be expected for a high-top camper) but the handling at speed, in any type or wind conditions or when passing or being passed by large vehicles, the van was…
Other Airstream Sprinter Westfalia years
No other model years have data.
Compare all Airstream Sprinter Westfalia years · All Airstream models
Frequently asked questions
Does the 2005 Airstream Sprinter Westfalia have any recalls?
No. NHTSA has no safety recalls for the 2005 Airstream Sprinter Westfalia as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.
What is the most common problem with the 2005 Airstream Sprinter Westfalia?
Owners report suspension problems most often (2 reports), followed by electrical system (2). The typical mileage when problems were reported is about 1,280 miles.
Are Airstream recall repairs free?
Yes. Safety recall repairs are free at authorized Airstream dealers, whether you are the first owner or bought the car used.