2006 Big Dog K-9 recalls and problems
The 2006 Big Dog K-9 has 4 safety recalls and 4 owner complaints filed with NHTSA. Recall repairs are free at any Big Dog dealer.
Recalls may cover only some 2006 Big Dog K-9 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2006 Big Dog K-9 recalls
Recall 07V-580: Structure
Problem: On certain motorcycles, the rear fender strut attaching bolts can fail allowing the rear fender to detach from the motorcycle.
Risk: This could occur without prior warning and could result in an injury or a crash.
Fix: Dealers will remove existing strut bolts and replace with higher tensile strength attaching bolts and updated washers. Higher torque values will be observed when installing the replacement fasteners. The recall began on january 21, 2008. Owners may contact big dog at 316-267-9121.
Recall 07V-356: Electrical System
Problem: On certain motorcycles, a warped bus bar within the voltage regulator can cause a short circuit.
Risk: This could possibly result in a fire.
Fix: Dealers will replace the existing circuit breaker located between the voltage regulator positive battery lead (B+ lead) and the positive battery terminal with an alternative circuit protection device that will prevent a thermal event if there is a short to ground. The recall began on october 1, 2007. Owners may contact big dog at 1-316-219-9129 or email to [email protected].
Recall 06V-305: Electrical System
Problem: On certain motorcycles, the electronic harness control (Ehc) module can fail resulting in a total shut down of the vehicle's electronic power.
Risk: This condition could occur without any prior warning and could result in a crash.
Fix: Dealers will replace the ehc modules free of charge. The recall began on september 19, 2006. Owners may contact big dog at 316-267-9121.
Recall 06V-019: Structure
Problem: On certain motorcycles, the kickstand spring may stretch and detach from the mounting bracket or the kickstand.
Risk: This will allow the kickstand to deploy into the extended position and cause a crash.
Fix: Dealers will install a new kickstand spring free of charge. The recall began on february 17, 2006. Owners may contact big dog at 316-267-9121.
2006 Big Dog K-9 problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Tires | 3 | |
| Electrical System | 1 |
Typical mileage at the time of the problem: 4,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2006 Big Dog K-9 complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Big Dog K-9 years
Frequently asked questions
Does the 2006 Big Dog K-9 have any recalls?
Yes — NHTSA lists 4 recalls for the 2006 Big Dog K-9: 07V-580 (structure), 07V-356 (electrical system), 06V-305 (electrical system), 06V-019 (structure). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2006 Big Dog K-9?
Owners report tires problems most often (3 reports), followed by electrical system (1). The typical mileage when problems were reported is about 4,000 miles.
Are Big Dog recall repairs free?
Yes. Safety recall repairs are free at authorized Big Dog dealers, whether you are the first owner or bought the car used.