2010 Chevrolet Cobalt recalls and problems
The 2010 Chevrolet Cobalt has 5 safety recalls and 574 owner complaints filed with NHTSA. Recall repairs are free at any Chevrolet dealer.
Recalls may cover only some 2010 Chevrolet Cobalt vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2010 Chevrolet Cobalt recalls
Recall 15V-500: Air Bags
Problem: General Motors LLC (GM) is recalling certain model year 2010 Chevrolet Cobalt vehicles manufactured January 4, 2010, to June 23, 2010. The affected vehicles may be equipped with an improperly routed Side-Impact Sensor (SIS) wiring harness in the driver side front door. The misrouted wiring harness could cause an electrical short that disables the driver side curtain air bag.
Risk: A disabled driver side roof-rail air bag will not deploy in the event of a crash necessitating deployment of that air bag, increasing the risk of injury to the driver.
Fix: GM will notify owners, and dealers will inspect the sensor's wiring in the driver's door and make repairs as necessary, free of charge. The recall began on September 8, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15075.
Recall 14V-171: Electrical System
Problem: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Fix: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Recall 14V-153: Steering
Problem: General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Risk: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Fix: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Recall 14V-047: Air Bags, Electrical System
Problem: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Fix: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMÂs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Recall 10V-073: Steering
Problem: General motors is recalling certain model year 2005-2010 chevrolet cobalt and model year 2007-2010 pontiac g5 vehicles equipped with electric power steering. The driver may experience a sudden loss of power steering assist that could occur at any time while driving.
Risk: If power steering assist is lost, it would require greater driver effort at low vehicle speeds, increasing the risk of a crash.
Fix: Dealers will replace the electric power steering motor free of charge. Owners are being notified on a rolling basis between march 29 through november 2010. A copy of the mailing schedule is located in the recall file. Owners may contact chevrolet at 1-800-630-2438 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.
2010 Chevrolet Cobalt problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Steering | 243 | |
| Electrical System | 128 | |
| Fuel/Propulsion System | 101 | |
| Air Bags | 77 | |
| Engine | 38 | |
| Power Train | 31 | |
| Unknown or Other | 28 | |
| Fuel System, Gasoline | 21 | |
| Service Brakes, Hydraulic | 14 | |
| Vehicle Speed Control | 14 | |
| Service Brakes | 14 | |
| Structure | 13 |
Most reported parts
- Structure › Body — 9
- Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, and Fittings — 9
- Electrical System › Ignition — 8
- Steering › Electric Power Assist System — 7
- Electrical System › Ignition › Switch — 5
- Structure › Body › Door — 2
- Equipment › Appliance › Air Conditioner — 2
- Electrical System › Instrument Cluster/Panel — 1
Typical mileage at the time of the problem: 64,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2010 Chevrolet Cobalt complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Chevrolet Cobalt years
Frequently asked questions
Does the 2010 Chevrolet Cobalt have any recalls?
Yes — NHTSA lists 5 recalls for the 2010 Chevrolet Cobalt: 15V-500 (air bags), 14V-171 (electrical system), 14V-153 (steering), 14V-047 (air bags, electrical system), 10V-073 (steering). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2010 Chevrolet Cobalt?
Owners report steering problems most often (243 reports), followed by electrical system (128). The typical mileage when problems were reported is about 64,000 miles.
Are Chevrolet recall repairs free?
Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.