There are no safety recalls for the 2003 Chevrolet Express 1500, but owners have filed 18 complaints with NHTSA.
2003 Chevrolet Express 1500 problems reported by owners
| Problem area | Reports | |
|---|
| Fuel System, Gasoline | 6 | |
| Fuel/Propulsion System | 4 | |
| Electrical System | 3 | |
| Seat Belts | 2 | |
| Structure | 2 | |
| Steering | 1 | |
| Latches/Locks/Linkages | 1 | |
| Engine and Engine Cooling | 1 | |
| Seats | 1 | |
Most reported parts
- Structure › Body — 2
- Electrical System › Horn — 1
- Electrical System › Wiring — 1
- Steering › Linkages › Tie Rod Assembly — 1
- Fuel System, Gasoline › Storage › Tank Assembly › Filler Pipe and Cap — 1
Typical mileage at the time of the problem: 107,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2003 Chevrolet Express 1500 complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Fuel/Propulsion System · at 124,000 miles · reported Dec 21, 2015
Corroded and leaking fuel filler neck. Foolish design involving dissimilar metals held in contact and surrounded with a conduit which holds water and road salt. Design is destined for failure. Gm has a partial recall for the snow belt. Such a foolish design should be fixed everywhere as it is just a matter of time until failure.
Structure · at 133,000 miles · reported Aug 13, 2015
The passenger side swing doors are very hard to open and shut and the drivers side swing doors are in the initial stage of this. The passenger swing door that is first to open (Right) does not want to open and doesn't want to shut. I have to force it. The second door (Left) is getting worse as well. This is causing the interior light pin in the door jam to not push in all the way, therefore; the lights will not shut off.
Fuel/Propulsion System · at 107,000 miles · reported Aug 26, 2014
The contact owns a 2003 chevrolet express 1500 van. The contact stated that when fueling the vehicle, fuel sprayed from the filler neck. The dealer diagnosed that fuel filler pipe needed to be replaced. The vehicle had not been repaired. The manufacturer had not been notified. The approximate failure mileage was 107,000.
Fuel/Propulsion System · at 148,000 miles · reported Jan 17, 2013
The contact owns a 2003 chevrolet express 1500. The contact stated that fuel was leaking from under the vehicle. The vehicle was taken to the dealer and to an independent mechanic for diagnostic testing. The technician and the mechanic advised that the return and delivery fuel lines would have to be replaced due to corrosion. The vehicle was not repaired. The approximate failure mileage was 148,000.
Fuel/Propulsion System · at 162,000 miles · reported May 22, 2012
On a few occasions prior to locating a leak, I noticed a gasoline smell. Finally when filling earlier this month, I saw a lot of leaking coming out of the fuel filler tube, between the metal tube and the plastic cover surrounding the tube. When I got home, I cut off the plastic tube about halfway and found a static wire running the length of the tube. Everywhere, where this wire touched to metal pipe, it was corroded completely through. The static wire is of a different material and was not corroded. Presently I have wrapped the tube with a gasoline resistant tape. But, I will have to replace…
Frequently asked questions
Does the 2003 Chevrolet Express 1500 have any recalls?
No. NHTSA has no safety recalls for the 2003 Chevrolet Express 1500 as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.
What is the most common problem with the 2003 Chevrolet Express 1500?
Owners report fuel system, gasoline problems most often (6 reports), followed by fuel/propulsion system (4). The typical mileage when problems were reported is about 107,000 miles.
Are Chevrolet recall repairs free?
Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.