There are no safety recalls for the 2005 Chevrolet SSR, but owners have filed 31 complaints with NHTSA.
2005 Chevrolet SSR problems reported by owners
| Problem area | Reports | |
|---|
| Latches/Locks/Linkages | 12 | |
| Structure | 6 | |
| Electrical System | 6 | |
| Power Train | 4 | |
| Air Bags | 2 | |
| Engine | 2 | |
| Fuel/Propulsion System | 2 | |
| Visibility | 1 | |
| Tires | 1 | |
| Seat Belts | 1 | |
| Engine and Engine Cooling | 1 | |
| Service Brakes | 1 | |
Most reported parts
- Latches/Locks/Linkages › Doors › Latch — 12
- Structure › Body › Door › Hinge and Attachments — 2
- Structure › Body — 2
- Visibility › Defroster/Defogger/Hvac System — 1
- Tires › Sidewall — 1
- Power Train › Driveline › Driveshaft — 1
- Electrical System › Instrument Cluster/Panel — 1
- Engine and Engine Cooling › Exhaust System › Emission Control › Catalytic Convertor — 1
Typical mileage at the time of the problem: 12,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Chevrolet SSR complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Electrical System · at 30,000 miles · reported Mar 9, 2021
Car started sfifting on its own while in motion. Was told to replace the TCM. The only thing I could do is to buy a used one. I was told mine was a 1 year build model. Very hard to find! Why if GM knew they were junk , are they not making replacments? This is there fault. There are no aftermarket ones. Also, I was told I need a fuse block. Also made by GM with no recall ! They are also defective! $50,000.00 for a death trap?
Electrical System · at 58,000 miles · reported Feb 25, 2016
The contact owns a 2005 chevrolet ssr. While the vehicle was parked, it failed to turn off without warning after numerous attempts. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was 58,000. ..updated 03/16/16 the consumer stated the engine and radio would not turn off, after the key was removed from the ignition. The alarm buzzer would not stop buzzing after the key was removed from the ignition. In order to turn off the engine, the consumer had to touch the brake and open and close the door, sometimes several times. Updated…
Fuel/Propulsion System · at 62,689 miles · reported Feb 16, 2016
Po463 code indicating fuel level sensor comes on then check engine light comes on. The fuel gauge will go to empty and back to full or existing fuel level. This occurs when vehicle is moving or stationary, with the engine running. Purchased from chevrolet dealer on 05/26/2015 (Third owner), and malfunction happened the same day, and the dealer would not make repairs, said sold as is. I have been trying to get fixed since then without any results. I recently heard that chevrolet provided a recall to correct or replace problem (Covering 10 yrs or 120,000 miles), but this vehicle was not fixed…
Electrical System · at 17,000 miles · reported Apr 14, 2014
The contact owns a 2005 chevrolet ssr. The contact stated that while driving 45 MPH, the vehicle stalled without warning. The vehicle was able to be restarted after several attempts. The vehicle was taken to an independent mechanic, who replaced the ignition switch however, the failure recurred twenty times over a period of four months. The manufacturer was not made aware of the failure. The approximate failure mileage was 17,000.
Power Train · at 74,000 miles · reported Dec 22, 2013
Engine over heats, electrical system malfunctions, speedometer cluster malfunctions, center switches malfunction, center switch failures. Fuel system malfunctions, fuel system delivery system make vehicle stall. Rear transmission seal leaks, clutch release spring spring out. Abs lights, oil lights & engine over heating lights comes on, transmission slave leaks. Engine fan malfunctions, it never comes on. Temperature gage locks, heat & gas gage locks. These issues has been brought to the attention of GM corporation. These guys refuse to pay for their manufacturing problems, they want to share…
Frequently asked questions
Does the 2005 Chevrolet SSR have any recalls?
No. NHTSA has no safety recalls for the 2005 Chevrolet SSR as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.
What is the most common problem with the 2005 Chevrolet SSR?
Owners report latches/locks/linkages problems most often (12 reports), followed by structure (6). The typical mileage when problems were reported is about 12,000 miles.
Are Chevrolet recall repairs free?
Yes. Safety recall repairs are free at authorized Chevrolet dealers, whether you are the first owner or bought the car used.