2008 Ford F-250 recalls and problems
The 2008 Ford F-250 has 5 safety recalls and 197 owner complaints filed with NHTSA. Recall repairs are free at any Ford dealer.
Recalls may cover only some 2008 Ford F-250 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.
2008 Ford F-250 recalls
Recall 08V-191: Fuel System, Gasoline
Problem: Ford is recalling 64,754 my 2008 f-250 and f-350 single rear wheel, 4x4, 156 inch wheel base pick up trucks equipped with a two piece drive shaft for failing to conform to the fuel spillage requirements of federal motor vehicle safety standard no. 301, "fuel system integrity." during a 30 MPH frontal impact into a rigid barrier, the fuel tank can move forward and contact a frame cross member, potentially causing damage to the fuel delivery module which can result in fuel spillage.
Risk: Fuel spillage, in the presence of an ignition source, could result in a fire.
Fix: Dealers will install a bracket on the affected vehicles free of charge. The recall began on may 23, 2008. Owners may contact ford at 1-800-392-3673.
Recall 08V-096: Seats
Problem: Ford is recalling 87,515 my 2008 f250, f-350, f-450, and f-550 vehicles for failing to comply with all the requirements of federal motor vehicle safety standard no. 207, "seating systems." some 40% split and captain's chair driver's seats, equipped with lumbar supports, may have improper welds at the joint of the seat back pivot bracket and the seat back frame.
Risk: In the event of a crash, the seat side pivot bracket may crack or break, increasing the risk of injury to the seat occupant.
Fix: Dealers will add a reinforcement to the driver's seat back frame on the 40% split or captain's chair seat equipped with lumbar support or, if necessary, the seat back frame will be replaced. The recall began on march 28, 2008. Owners may contact ford at 1-800-392-3673.
Recall 07V-541: Air Bags
Problem: Certain vehicles fail to conform to the requirements specified in federal motor vehicle safety standard no. 208, 'occupant crash protection.' the driver air bag module may not have been properly assembled.
Risk: This condition may prevent the driver air bag from properly deploying and reduce occupant protection in the event of a crash.
Fix: Dealers will replace your driver air bag module free of charge. The recall began on november 20, 2007. Owners may contact ford at 1-800-392-3673.
Recall 07V-140: Electrical System
Problem: On certain trucks equipped with a 6.4l diesel engine, insufficient clearance of the battery positive (B+) wire to the right hand splash shield bolt may result in the battery b+ wire contacting the splash shield bolt.
Risk: Long term contact could cause wire chafe, resulting in copper wire being exposed. If this condition occurs, the battery b+ wire could short to ground increasing the risk of a fire.
Fix: Dealers will inspect the battery b+ wire location and, if necessary, reposition the wire. The recall began on april 3, 2007. Owners may contact ford at 1-800-392-3673.
Recall 07V-139: Power Train
Problem: On certain trucks equipped with a 6.4l diesel engine, excessive temperatures in the diesel particulate filter in the exhaust system may result from excess hydrocarbons in the exhaust.
Risk: Lack of power or rough operation, unusual noises from the engine or exhaust, white smoke from the exhaust, and potentially a visible flame out the tailpipe can occur.
Fix: Dealers will reprogram the power train control module. The recall began on april 3, 2007. Owners may contact ford at 1-800-392-3673.
2008 Ford F-250 problems reported by owners
| Problem area | Reports | |
|---|---|---|
| Steering | 81 | |
| Suspension | 35 | |
| Engine | 19 | |
| Engine and Engine Cooling | 16 | |
| Tires | 16 | |
| Power Train | 14 | |
| Electrical System | 12 | |
| Service Brakes | 11 | |
| Vehicle Speed Control | 8 | |
| Unknown or Other | 8 | |
| Service Brakes, Hydraulic | 7 | |
| Structure | 5 |
Most reported parts
- Suspension › Front — 4
- Engine and Engine Cooling › Exhaust System — 3
- Engine and Engine Cooling › Engine › Diesel — 2
- Service Brakes, Hydraulic › Pedals and Linkages — 2
- Engine and Engine Cooling › Cooling System › Radiator Assembly — 2
- Structure › Body — 2
- Power Train › Automatic Transmission — 1
- Power Train › Transfer Case (4-Wheel Drive) — 1
Typical mileage at the time of the problem: 70,000 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2008 Ford F-250 complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Other Ford F-250 years
Frequently asked questions
Does the 2008 Ford F-250 have any recalls?
Yes — NHTSA lists 5 recalls for the 2008 Ford F-250: 08V-191 (fuel system, gasoline), 08V-096 (seats), 07V-541 (air bags), 07V-140 (electrical system), 07V-139 (power train). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.
What is the most common problem with the 2008 Ford F-250?
Owners report steering problems most often (81 reports), followed by suspension (35). The typical mileage when problems were reported is about 70,000 miles.
Are Ford recall repairs free?
Yes. Safety recall repairs are free at authorized Ford dealers, whether you are the first owner or bought the car used.