2007 Itasca Navion recalls and problems

The 2007 Itasca Navion has 1 safety recall and 5 owner complaints filed with NHTSA. Recall repairs are free at any Itasca dealer.

Recalls

Complaints

Crashes / fires

0 / 0

Injuries / deaths

0 / 0

Recalls may cover only some 2007 Itasca Navion vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2007 Itasca Navion recalls

Recall 10V-470: Seat Belts

Reported Oct 5, 2010 · 2,496 vehicles affected · WINNEBAGO INDUSTRIES, INC.

Problem: Winnebago is recalling certain model year 2006 through 2011 winnebago view and itasca navion motor homes because the dinette area seat belt restraints on those vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 210, "seat belt assembly anchorages." in a collision, the generated crash forces can cause the restraint's attachment to tear and allow the anchor to separate from the body of the vehicle.

Risk: If the restraint separates from the vehicle during a crash, the belt will not properly restrain the seat occupant, increasing the risk of injury or death to the occupant.

Fix: Winnebago will add additional seat belt anchorages free of charge. The safety recall began on november 12, 2010. Owners may contact winnebago at 1-800-537-1885.

2007 Itasca Navion problems reported by owners

Problem area	Reports
Engine and Engine Cooling	4
Power Train	1
Steering	1
Fuel/Propulsion System	1

Most reported parts

Engine and Engine Cooling › Exhaust System — 2
Engine and Engine Cooling › Engine › Other Fuel Types › Turbo/Supercharger — 1
Engine and Engine Cooling › Engine › Diesel — 1
Steering › Hydraulic Power Assist › Pump — 1

Typical mileage at the time of the problem: 15,649 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2007 Itasca Navion complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Fuel/Propulsion System · at 36,865 miles · reported Aug 29, 2017

Failure of the plastic turbo noise dampener caused immediate loss of power and placing us in a precarious situation while going uphill on a busy highway.

Engine and Engine Cooling · reported Apr 17, 2012

Consumer writes in regards to early failures on mercedes 642 v6 engine the consumer purchased a winnebago navion motorhome which came equipped with an engine manufactured by mercedes. The consumer stated the rv started to shift in a strange manner after a few hundred miles, then after a thousand miles, the shifting became very erratic, so the consumer did mostly manually shifting. After the EGR was replaced, the rv shifted fine. However, at 23,576 miles, the power steering pump failed and two pins the held the pump in place failed.

Engine and Engine Cooling · at 15,139 miles · reported Jul 17, 2010

The turbo resonators on 2002-2007, 2.7 mercedes benz diesel engines are defective! I AM on my third one, and I only have 15,000 miles on my engine, which is in a 2007 itasca navion motor home. When they go out on the interstate, you are put in a very dangerous situation because you cannot go over 45 MPH, and you're life is put in danger. I have emailed mercedes benz/dodge/winnebago and they say they don't have a problem, but they do!! I have gone online searching out this defect and could not believe the number of people who have experienced this same life or death situation, due to their…

Engine and Engine Cooling · at 15,649 miles · reported Jun 2, 2010

I have a 2007 itasca navion with a 2.7 mercedes benz diesel engine on a dodge sprinter chassis. This past saturday, may 29, 2010, I had to take my rv into kings dodge to have my third resonator replaced because when one goes out, you cannot go over 45 MPH on the interstate, and this is dangerous. My rv only has 15,649 miles on it!, so I think that a recall needs to be made, by you, so mercedes benz corrects this resonator problem. I got online with this problem and could not believe the number of resonator complaints there were. Thank you for your help..

Engine and Engine Cooling · at 401 miles · reported Jul 19, 2007

While driving on the expressway in my 2007 itasca navion, the turbo resonator failed. That caused the speed to drop quickly to 40 MPH. I nearly avoided an accident with a truck that was behind me. The part is made of plastic and is in a hot environment. The seams separate and causes the vehicle to go into limp home mode. This defect has been discussed widely in several internet forums. The part was replaced by a dodge sprinter dealer and the parts man said that they have replaced many of them.

Other Itasca Navion years

2023 2022 2021 2020 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 200820072006

Compare all Itasca Navion years · All Itasca models

Frequently asked questions

Does the 2007 Itasca Navion have any recalls?

Yes — NHTSA lists 1 recall for the 2007 Itasca Navion: 10V-470 (seat belts). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2007 Itasca Navion?

Owners report engine and engine cooling problems most often (4 reports), followed by power train (1). The typical mileage when problems were reported is about 15,649 miles.

Are Itasca recall repairs free?

Yes. Safety recall repairs are free at authorized Itasca dealers, whether you are the first owner or bought the car used.