2005 Jeep Wrangler recalls and problems

The 2005 Jeep Wrangler has 1 safety recall and 650 owner complaints filed with NHTSA. Recall repairs are free at any Jeep dealer.

Recalls

Complaints

650

Crashes / fires

10 / 9

Injuries / deaths

15 / 2

Recalls may cover only some 2005 Jeep Wrangler vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2005 Jeep Wrangler recalls

Recall 05V-460: Power Train

Reported Oct 6, 2005 · 256,409 vehicles affected · DAIMLERCHRYSLER CORPORATION

Problem: On certain pickup trucks, sport utility and passenger vehicles equipped with 42rle automatic transmissions, the cup plug that retains the park pawl anchor shaft may be improperly installed. If the shaft moves out of position, the vehicle may not be able to achieve 'park' position.

Risk: If this occurs and the parking brake is not applied, the vehicle may roll away and cause a crash without warning.

Fix: Dealers will inspect the transmissions and install a bracket to ensure the park pawl anchor shaft is retained in the proper position. The recall began on november 28, 2005. Owners may contact daimlerchrysler at 1-800-853-1403.

2005 Jeep Wrangler problems reported by owners

Problem area	Reports
Fuel System, Gasoline	352
Fuel/Propulsion System	99
Steering	58
Suspension	52
Power Train	41
Engine and Engine Cooling	22
Electrical System	20
Engine	19
Service Brakes, Hydraulic	14
Unknown or Other	11
Structure	10
Vehicle Speed Control	10

Most reported parts

Suspension › Front — 10
Fuel System, Gasoline › Storage › Tank Assembly › Filler Pipe and Cap — 8
Power Train › Manual Transmission — 7
Power Train › Automatic Transmission — 6
Service Brakes, Hydraulic › Foundation Components › Disc › Rotor — 6
Structure › Body — 6
Engine and Engine Cooling › Engine — 5
Fuel System, Gasoline › Storage › Tank Assembly — 5

Typical mileage at the time of the problem: 50,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2005 Jeep Wrangler complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Engine · at 154,000 miles · reported Aug 21, 2026

The contact owns a 2005 Jeep Wrangler. The contact stated that while driving 55 MPH, the vehicle stalled. The check engine warning light was flashing. The contact pulled over to the side of the road. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to three different independent mechanics to be diagnosed, and the third mechanic diagnosed the vehicle with camshaft failure. The vehicle was not repaired. The dealer was contacted and referred the contact to the manufacturer. The manufacturer informed the contact that the vehicle was not covered under…

Engine · reported Oct 5, 2023

Engine warning light has been coming on since about 70k miles(190k now). Scanner says O2 sensor is bad. After replacement of the O2 sensor, the fault continues to show up randomly. I carry a scanner to reset the engine code on the road. All wiring has been checked and is ok. When I clear the code, the error does not show up again for anywhere from 125 miles to around 300 miles. Clearing the code starts the process all over.

Steering · reported Mar 6, 2023

As I was driving home from work on Feb. 14, 2023, in Rocky Hill, NJ. the vehicle developed a sudden loss of steering control. I had it towed to Chrysler Dodge Jeep RAM of Princeton, NJ. The service manager informed me that the area of the frame to which the steering gear box is bolted had completely rotted, and the steering box had separated. The car was not driveable and could not be repaired. The vehicle will be available for inspection until April 15, 2023.

Power Train · reported Aug 27, 2022

Ecm computer , o2 heater sensor from ecm and controls transmission shift points . Replaced o2 sensors and transmission is controlled by ecm not shifting correctly will stay in first gear and hard shift to second can create loss of control in wet weather conditions.

Power Train · reported Jul 14, 2021

The dashboard will display odd behavior and all of a sudden the ignition will cut. Total loss of power. This has happened in the past with children in the vehicle. Very dangerous. Resetting the key will reset but it is random.

Other Jeep Wrangler years

2026 2025 2024 2023 2022 2021 2020 2019 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2008 2007 200620052004 2003 2002 2001 2000

Compare all Jeep Wrangler years · All Jeep models

Frequently asked questions

Does the 2005 Jeep Wrangler have any recalls?

Yes — NHTSA lists 1 recall for the 2005 Jeep Wrangler: 05V-460 (power train). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2005 Jeep Wrangler?

Owners report fuel system, gasoline problems most often (352 reports), followed by fuel/propulsion system (99). The typical mileage when problems were reported is about 50,000 miles.

Are Jeep recall repairs free?

Yes. Safety recall repairs are free at authorized Jeep dealers, whether you are the first owner or bought the car used.