2000 Kawasaki ZX1200-A1 recalls and problems

The 2000 Kawasaki ZX1200-A1 has 3 safety recalls and 12 owner complaints filed with NHTSA. Recall repairs are free at any Kawasaki dealer.

Recalls

Complaints

Crashes / fires

2 / 1

Injuries / deaths

0 / 0

Recalls may cover only some 2000 Kawasaki ZX1200-A1 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2000 Kawasaki ZX1200-A1 recalls

Recall 01V-323: Tires

Reported Oct 10, 2001 · 6,305 vehicles affected · KAWASAKI MOTORS CORP.

Problem: Vehicle description: motorcycles. The nuts securing the tire valve stems to the wheels can fail, resulting in a loss of tire air pressure.

Risk: If this occurs, air pressure will be lost from the wheel/tire, resulting in the possibility of loss of control.

Fix: Dealers will replace the valve nut and washer. Owner notification began october 25, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact kawasaki at 1-949-770-0400.

Recall 00V-384: Fuel System, Gasoline

Reported Nov 21, 2000 · 3,279 vehicles affected · KAWASAKI MOTORS CORP.

Problem: Vehicle description: motorcycles. The fuel gauge and low fuel warning system may not provide accurate indication of low fuel levels.

Risk: The operator could run out of fuel without warning, causing the operator to become distracted, or to slow unexpectedly in traffic, creating the risk of a crash.

Fix: Dealers will replace the fuel gauge sending components.

Recall 00V-365: Fuel System, Gasoline

Reported Nov 14, 2000 · 4,506 vehicles affected · KAWASAKI MOTORS CORP.

Problem: Vehicle description: motorcycles. A leaking vent pipe in the fuel tank can allow fuel to drain onto the ground.

Risk: Fuel leakage in the presence of an ignition source can result in a fire.

Fix: Dealers will insert a supporting brace into the tank to dampen any effects of vibration on the vent pipe.

2000 Kawasaki ZX1200-A1 problems reported by owners

Problem area	Reports
Electrical System	3
Fuel System, Gasoline	2
Power Train	2
Engine and Engine Cooling	2
Suspension	1
Tires	1
Exterior Lighting	1
Steering	1

Most reported parts

Fuel System, Gasoline › Storage › Tank Assembly — 2
Power Train › Clutch Assembly › Pedal/Hand Lever(Motorcycle) — 2
Tires › Valve — 1
Exterior Lighting › Headlights — 1
Steering › Hydraulic Power Assist › Hose, Piping, and Connections — 1
Electrical System › Wiring — 1
Electrical System › Wiring › Fuses and Circuit Breakers — 1

Typical mileage at the time of the problem: 10,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2000 Kawasaki ZX1200-A1 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Electrical System · at 22,000 miles · reported Jun 2, 2006

Wires connectors that attach the regulator/rectifier and stator melted. White smoke was emitting from under the rear seat. After removing the seat, I notice that oil was present in the area surrounding the regulator/rectifier and one of wires had burn loose. This also caused the junction/box headlight relay switch to fail. I received a $175 equipment failure ticket. Fortunately it was about 6:00 PM and still light out. I call the locate kawasaki dealer to see if there were any recalls. I had to cut wires to the regulator/rectifier, stator and solder/crimp, because the connector was badly…

Steering · at 36,000 miles · reported Jun 4, 2004

Consumer states that the stator wire connection is leaking oil under the rear seat, causing oil to leak onto rear tire, and create a short to the rear connector, resulting in a fire hazard. Leaking oil caused the connector to melt.

Exterior Lighting · at 5,800 miles · reported Jun 12, 2003

After driving for about 100 miles in the rain, headlight fuse blew, causing the complete failure of both headlights. There have been numerous similar incidents documented on websites.

Engine and Engine Cooling · at 10,000 miles · reported Jan 27, 2003

While turning corner at 30 MPH, back tire spun out of control due to a oil leakage, resulting in consumer hitt a tree and motorcycle was totaled. A week later the consumer recieved a recall notice on oil leakage. Please provide addditional information.

Engine and Engine Cooling · at 10,000 miles · reported Jan 27, 2003

While turning corner at 30 MPH, the back tire spun out of control due to a oil leakage, resulting in consumer hitting a tree ,and motorcycle was totaled. A week later consumer recieved a recall notice on oil leakage. Please provide addditional information.

Other Kawasaki ZX1200-A1 years

No other model years have data.

Compare all Kawasaki ZX1200-A1 years · All Kawasaki models

Frequently asked questions

Does the 2000 Kawasaki ZX1200-A1 have any recalls?

Yes — NHTSA lists 3 recalls for the 2000 Kawasaki ZX1200-A1: 01V-323 (tires), 00V-384 (fuel system, gasoline), 00V-365 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2000 Kawasaki ZX1200-A1?

Owners report electrical system problems most often (3 reports), followed by fuel system, gasoline (2). The typical mileage when problems were reported is about 10,000 miles.

Are Kawasaki recall repairs free?

Yes. Safety recall repairs are free at authorized Kawasaki dealers, whether you are the first owner or bought the car used.