Home › Suzuki › VL1500T › 2005

2005 Suzuki VL1500T recalls and problems

The 2005 Suzuki VL1500T has 1 safety recall and 3 owner complaints filed with NHTSA. Recall repairs are free at any Suzuki dealer.

Recalls
1
Complaints
3
Crashes / fires
0 / 0
Injuries / deaths
0 / 0

Recalls may cover only some 2005 Suzuki VL1500T vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2005 Suzuki VL1500T recalls

Recall 06V-025: Fuel System, Gasoline

Reported Jan 30, 2006 · 37,911 vehicles affected · AMERICAN SUZUKI MOTOR CORP.

Problem: On certain motorcycles, stress around the right front fuel tank mounting point can cause hairline fatigue cracks to form. This can result in a fuel leak.

Risk: In the presence of an ignition source, a fuel leak can result in a fire.

Fix: Dealers will inspect the fuel tank and install improved cushions that mount and support the fuel tank. Any fuel tanks that are found to have a crack will be replaced. If a tank is found to have a crack and a replacement tank is not available, fuel tank sealant will be applied to the tank as an interim repair. When the replacement tank becomes available, the owner will be contacted and a replacement tank will be installed. The recall began on february 3, 2006. Owners may contact suzuki at 1-714-572-1490.

2005 Suzuki VL1500T problems reported by owners

Problem areaReports
Electrical System2
Fuel System, Gasoline1

Typical mileage at the time of the problem: 13,880 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2005 Suzuki VL1500T complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Fuel System, Gasoline · at 10,560 miles · reported Jun 27, 2022
The contact owns a 2005 Suzuki VL1500T Motorcycle. The contact stated that while riding at an undisclosed speed, a fuel odor was detected. The motorcycle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 10,560.
Electrical System · at 31,000 miles · reported Aug 18, 2011
Stator failed at 70-75mph in interstate traffic with no warning!! Just heard a loud pop! And then no power at all! No power to the bike what so ever. Happened again after replacing stator. 500 miles later! Again no warning, just a loud pop and no power whatsoever. Only this time I was on a back road. There is no way this isn't a safety issue! The rectifer/regulator on this motorcycle is the same part# that is under a recall notice by suzuki. Why these bikes weren't included is a mystery to me?? The electrical system has been a weak link with these bikes since their inception. But in 05 when…
Electrical System · at 13,880 miles · reported Aug 17, 2011
I have a 2005 suzuki vl1500t and I have had to have the stator replace on my bike after it only has 13,880 miles. In 2010 while riding my bike it went dead and I had to coast my way to the side of the road during traffic. After replacing my battery the bike worked perfectly. Then a few months later I road my bike to work and went to lunch around 1pm. When I got ready to go home around 4pm it would not start. After getting the bike home I placed it on my battery plus tender charger and within a couple of hours it started right up. I left the bike on the charger till the next morning. The next…

Other Suzuki VL1500T years

20062005

Compare all Suzuki VL1500T years · All Suzuki models

Frequently asked questions

Does the 2005 Suzuki VL1500T have any recalls?

Yes — NHTSA lists 1 recall for the 2005 Suzuki VL1500T: 06V-025 (fuel system, gasoline). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2005 Suzuki VL1500T?

Owners report electrical system problems most often (2 reports), followed by fuel system, gasoline (1). The typical mileage when problems were reported is about 13,880 miles.

Are Suzuki recall repairs free?

Yes. Safety recall repairs are free at authorized Suzuki dealers, whether you are the first owner or bought the car used.