2004 Winnebago Adventurer recalls and problems

The 2004 Winnebago Adventurer has 3 safety recalls and 22 owner complaints filed with NHTSA. Recall repairs are free at any Winnebago dealer.

Recalls

Complaints

Crashes / fires

1 / 1

Injuries / deaths

1 / 0

Recalls may cover only some 2004 Winnebago Adventurer vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2004 Winnebago Adventurer recalls

Recall 10V-525: Equipment

Reported Oct 26, 2010 · 18,461 vehicles affected · WINNEBAGO INDUSTRIES, INC.

Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.

Fix: Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.

Recall 04V-609: Fuel System, Gasoline

Reported Dec 22, 2004 · 3,538 vehicles affected · WINNEBAGO INDUSTRIES, INC.

Problem: On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.

Risk: Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. Fuel leakage, in the presence of an ignition source, could result in a fire.

Fix: Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began january 7, 2005. Owners should contact winnebago at 1-800-537-1885.

Recall 04V-608: Seat Belts

Reported Dec 18, 2004 · 6,201 vehicles affected · WINNEBAGO INDUSTRIES, INC.

Problem: Certain seat belt buckles on some motor homes fail to conform to the load requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."

Risk: The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.

Fix: Dealers will replace the buckles. The recall began on november 12, 2004. Owners should contact amsafe at 1-574-266-8330 or winnebago at 1-800-537-1885.

2004 Winnebago Adventurer problems reported by owners

Problem area	Reports
Service Brakes, Hydraulic	10
Fuel System, Gasoline	3
Electrical System	3
Equipment	3
Suspension	2
Visibility	2
Wheels	1
Tires	1
Seat Belts	1
Structure	1
Seats	1
Service Brakes, Air	1

Most reported parts

Electrical System › Wiring › Fuses and Circuit Breakers — 2
Tires › Valve — 1
Electrical System › Wiring — 1
Seat Belts › Front › Retractor — 1
Visibility › Glass, Side/Rear — 1
Equipment › Appliance › Air Conditioner — 1
Service Brakes, Air › Drum — 1
Power Train › Automatic Transmission — 1

Typical mileage at the time of the problem: 15,575 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2004 Winnebago Adventurer complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Service Brakes, Hydraulic · at 25,000 miles · reported Oct 28, 2014

The contact owns a 2004 winnebago adventurer. The contact stated that all four rotors were deteriorated to the point of potentially fracturing. The contact mentioned that the rotors were cracked. The manufacturer was made aware of the failure and referred the contact to an authorized dealer. The technician informed the contact that the vehicle was included in an unknown manufacturer recall related to the calipers; however, the parts were not available and prevented the dealer from repairing the rotor failure. Once the parts became available, both the calipers and rotors were replaced by the…

Fuel System, Gasoline · at 30,630 miles · reported Sep 18, 2013

On 09/13/13 I noticed an odor of gas near drivers side rear tires. I slid under motorhome and noticed wet area on gas tank. I inspected the gas tank and found gas leaking from a spot weld for the internal baffle in the gas tank. This is a serious problem that could cause a fire, generator is close by. Leak could also be ignited from a spark from a campfire while parked at a campground.

Fuel System, Gasoline · at 40,000 miles · reported Apr 20, 2011

The contact owns a 2004 winnebago adventurer rv. The vehicle was parked when the contact noticed fuel leaking from the fuel tank. The vehicle was taken to an authorized dealer where the contact was told that there was a hole within an internal weld on the fuel tank. The fuel tank was replaced. Approximately three years later, the failure recurred. The vehicle was not taken to have the failure diagnosed. The vehicle was not repaired a second time. The failure mileage was 40,000 and the current mileage was 61,000.

Service Brakes, Hydraulic · reported Nov 30, 2010

Workhorse custom chassis safety recall 51101-c, replacement of bosch service brake calipers. Dealer intentionally failed to have calipers replaced prior to sale of vehicle. Purchaser of vehicle complained to dealer that tires were bad and, after removing tires, that brake pads, calipers and rotors were also bad. Dealer refused to remedy any of the complaints and neglected to inform purchaser of vehicle of the safety recall for nearly 2 weeks after sale.

Service Brakes, Hydraulic · at 9,314 miles · reported Sep 17, 2010

There have been repeated attempts to repair the ABS system on my class a motorhome,since the time of purchase, including 1 manufacturer recall on the ABS system and 2 recalls on the hydraulic brakes. I have completed all of the recall orders and also had intermittent inspections on the brakes. This morning I had an accident due to a brake failure. The brake pedal went to the floor without slowing the vehicle and I went through a stop sign, across a state highway, over an incline and through a fence.

Other Winnebago Adventurer years

2025 2024 2023 2022 2021 2020 2019 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2008 2007 2006 200520042003 2002 2001 2000

Compare all Winnebago Adventurer years · All Winnebago models

Frequently asked questions

Does the 2004 Winnebago Adventurer have any recalls?

Yes — NHTSA lists 3 recalls for the 2004 Winnebago Adventurer: 10V-525 (equipment), 04V-609 (fuel system, gasoline), 04V-608 (seat belts). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2004 Winnebago Adventurer?

Owners report service brakes, hydraulic problems most often (10 reports), followed by fuel system, gasoline (3). The typical mileage when problems were reported is about 15,575 miles.

Are Winnebago recall repairs free?

Yes. Safety recall repairs are free at authorized Winnebago dealers, whether you are the first owner or bought the car used.