There are no safety recalls for the 2005 Yamaha FZ6, but owners have filed 14 complaints with NHTSA.
2005 Yamaha FZ6 problems reported by owners
| Problem area | Reports | |
|---|
| Engine and Engine Cooling | 6 | |
| Electrical System | 4 | |
| Fuel System, Gasoline | 3 | |
| Vehicle Speed Control | 3 | |
| Exterior Lighting | 2 | |
| Wheels | 1 | |
| Service Brakes, Hydraulic | 1 | |
| Power Train | 1 | |
| Tires | 1 | |
| Engine | 1 | |
Most reported parts
- Fuel System, Gasoline › Delivery — 2
- Electrical System › Ignition — 2
- Engine and Engine Cooling › Engine — 2
- Wheels › Lugs/Nuts/Bolts/Studs — 1
- Service Brakes, Hydraulic › Foundation Components › Disc — 1
- Exterior Lighting › Tail Lights — 1
- Power Train › Clutch Assembly — 1
- Exterior Lighting › Headlights — 1
Typical mileage at the time of the problem: 4,800 miles (median of owner reports).
Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.
Recent 2005 Yamaha FZ6 complaints
Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.
Vehicle Speed Control · reported Feb 25, 2022
Hello, i ride this Yamaha FZ-6 motorcycle and I experience poor idling and engine stalls during riding, and last time this nearly led to accident, because the motorcycle slowed down in front of an overpassing automobile. I have bought this bike imported from USA. I am situated in Bulgaria, Europe. I saw there is a recall action about faulty TPS sensor. Kindly requesting any help for replacing this sensor by recall action. Thank you in advance for your kind support. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Engine and Engine Cooling · at 5,225 miles · reported Feb 28, 2009
Engine oil pan cracked after torquing drain plug to manufacturers spec. Have read many other complaints of this same occurrence. Contacted local dealer and yamaha america. Both declined knowledge of defect. Yamaha america was quite short, did not want to hear any details of the failure, just stated that there were no recalls, any defects were no longer under warranty.
Electrical System · at 4,000 miles · reported Sep 15, 2006
My 2005 fz6 ran flawlessly till 4000 mile then the idle was dropping to 600-800 and then would just die. I would turn key off and turn key on again and restart and it would run fine. It happens twice a week. Once on wet pavement it was feeling boggish I pulled clutch to see and it was 600-800 and died. I let out clutch and almost lost it. I read about several other owners experiencing same problem and some rumor it to the tps sensor.
Vehicle Speed Control · at 17,648 miles · reported Jun 29, 2006
Motorcycle has been idling poorly and stalling when coming off interstate riding. Gas mileage has also been dropping. Only recently, motorcycle stalled in center lane of highway at traffic signal at night, would not restart. Received fault code 15 corresponding to throttle position sensor. Replaced part. Learned of several other 2005 fz6's with similar problem.
Fuel System, Gasoline · at 3,690 miles · reported May 25, 2006
I was riding home on my 2005 yamaha fz6 motorcycle, when the engine began idling very rough. I had to roll on the throttle to keep the engine from stalling. Then a few seconds later I pulled in the clutch and the engine stalled completely. I was not able to restart the engine after 4 attempts. Then I turned the ignition off, and turned it back on, and the engine started as if there was no problem. Obviously, turning the ignition off and back on is merely a band aid for this issue, and not a permanent solution. Please refer to this website to learn of other fz6 owners that have experienced this…
Frequently asked questions
Does the 2005 Yamaha FZ6 have any recalls?
No. NHTSA has no safety recalls for the 2005 Yamaha FZ6 as of this update. Check your VIN at nhtsa.gov/recalls for the latest status.
What is the most common problem with the 2005 Yamaha FZ6?
Owners report engine and engine cooling problems most often (6 reports), followed by electrical system (4). The typical mileage when problems were reported is about 4,800 miles.
Are Yamaha recall repairs free?
Yes. Safety recall repairs are free at authorized Yamaha dealers, whether you are the first owner or bought the car used.