Home › GMC › Envoy XL › 2004

2004 GMC Envoy XL recalls and problems

The 2004 GMC Envoy XL has 1 safety recall and 187 owner complaints filed with NHTSA. Recall repairs are free at any GMC dealer.

Recalls
1
Complaints
187
Crashes / fires
6 / 6
Injuries / deaths
8 / 0

Recalls may cover only some 2004 GMC Envoy XL vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2004 GMC Envoy XL recalls

Recall 04V-527: Exterior Lighting

Reported Nov 1, 2004 · 871,473 vehicles affected · GENERAL MOTORS CORP.

Problem: On certain sport utility vehicles, vibration and heat may cause the tail lamp/stop lamp bulb to loosen in its socket. If this occurs, the bulb may flicker and eventually become inoperative.

Risk: An inoperative brake lamp will not convey the driver's intention of stopping to drivers in following vehicles, and an inoperative rear turn signal lamp will not convey the driver's intention to turn to drivers in following vehicles. Both of these failures can increase the risk of a crash.

Fix: Dealers will inspect the tail lamp/stop lamp assemblies, and if necessary, replace them. The recall began on november 22, 2004. Owners should contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, buick at 1-866-608-8080, or gmc at 1-866-996-9463.

2004 GMC Envoy XL problems reported by owners

Problem areaReports
Electrical System83
Power Train21
Fuel System, Gasoline20
Engine and Engine Cooling15
Exterior Lighting11
Vehicle Speed Control9
Visibility9
Fuel/Propulsion System8
Air Bags7
Tires5
Equipment5
Service Brakes, Hydraulic5

Most reported parts

  • Electrical System › Instrument Cluster/Panel — 37
  • Power Train › Automatic Transmission — 6
  • Exterior Lighting › Turn Signal — 3
  • Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 3
  • Exterior Lighting › Headlights — 3
  • Fuel System, Gasoline › Storage › Tank Assembly — 3
  • Engine and Engine Cooling › Exhaust System — 3
  • Electrical System › Ignition › Switch — 2

Typical mileage at the time of the problem: 66,428 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2004 GMC Envoy XL complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Engine · reported Apr 14, 2023
The contact owns a 2004 GMC Envoy XL. The contact stated while driving approximately 45 MPH, the accelerator pedal was depressed, and the vehicle stalled. Additionally, the vehicle failed to restart, with several unknown warning lights illuminated. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and suggested that the vehicle be inspected by a local dealer. The failure mileage was unknown.
Power Train · reported Aug 8, 2019
I was driving back home, pulled in my driveway, put the vehicle in park and when I released the brake pedal the vehicle jumped and took off in reverse. I missed hitting my wife by inches. I stopped and restarted the vehicle. It would not start. I tried to push the button on the shifter.I internet searched it was said to be the lockout devise. I inspected the trans and found the cable that come from the shifter to the trans was off and trans bracket was worn from use. If it happened in a parking lot I could have hit someone or the vehicle behind me. I contacted gmc no knowledge of the safety…
Electrical System · at 145,000 miles · reported Dec 29, 2018
Driving at a low speed down hill on a city street, with the car in the drive position, the car stalled. This happened again driving on a flat service of a parking lot of a shopping center. Again, with the car in the drive position going at a low speed the car stalled.
Air Bags · at 85,000 miles · reported Oct 4, 2018
Four vehicle accident, #three vehicle in line from the front. Traveling at posted speed limit of 60mph. Sudden hard braking, hit in the front & rear of the vehicle, vehicle was considered a total right off. No air bag deployment on driver or passenger in front seat! Rush hour traffic on four lane st. Hwy., dfw, tx. March of 2014.
Power Train · at 140,395 miles · reported Aug 6, 2018
The contact owns a 2004 gmc envoy xl. While driving approximately 60 MPH, the vehicle inadvertently decelerated. The contact stopped at a fuel station and proceeded to check all the fluid levels. The contact continued to drive and the check engine warning indicator illuminated. The contact could only operate the vehicle in first and second gears. The vehicle was taken to an independent mechanic who determined that the transmission failed and needed replacement. The vehicle was not repaired. The dealer was not contacted. The manufacturer was made aware of the failure and complaint number…

Other GMC Envoy XL years

2006200420032002

Compare all GMC Envoy XL years · All GMC models

Frequently asked questions

Does the 2004 GMC Envoy XL have any recalls?

Yes — NHTSA lists 1 recall for the 2004 GMC Envoy XL: 04V-527 (exterior lighting). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2004 GMC Envoy XL?

Owners report electrical system problems most often (83 reports), followed by power train (21). The typical mileage when problems were reported is about 66,428 miles.

Are GMC recall repairs free?

Yes. Safety recall repairs are free at authorized GMC dealers, whether you are the first owner or bought the car used.