Home › GMC › Yukon XL › 2002

2002 GMC Yukon XL recalls and problems

The 2002 GMC Yukon XL has 1 safety recall and 95 owner complaints filed with NHTSA. Recall repairs are free at any GMC dealer.

Recalls
1
Complaints
95
Crashes / fires
5 / 1
Injuries / deaths
2 / 0

Recalls may cover only some 2002 GMC Yukon XL vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2002 GMC Yukon XL recalls

Recall 05V-379: Service Brakes, Hydraulic

Reported Aug 29, 2005 · 1,353,718 vehicles affected · GENERAL MOTORS CORP.

Problem: Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (Abs) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.

Risk: This can cause increased stopping distances during low-speed brake applications, which could result in a crash.

Fix: Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.

2002 GMC Yukon XL problems reported by owners

Problem areaReports
Service Brakes, Hydraulic19
Steering13
Tires10
Fuel System, Gasoline10
Engine and Engine Cooling10
Power Train9
Service Brakes9
Parking Brake8
Electrical System4
Structure4
Visibility3
Suspension3

Most reported parts

  • Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 10
  • Fuel System, Gasoline › Delivery › Fuel Pump — 6
  • Tires › Tread/Belt — 3
  • Power Train › Transfer Case (4-Wheel Drive) — 3
  • Steering › Column — 3
  • Fuel System, Gasoline › Storage › Tank Assembly — 2
  • Power Train › Automatic Transmission — 2
  • Steering › Gear Box › Shaft Sector — 2

Typical mileage at the time of the problem: 64,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2002 GMC Yukon XL complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Service Brakes · at 189,000 miles · reported Jun 23, 2022
The contact owns a 2002 GMC Yukon XL. The contact stated while driving approximately 70 MPH, the contact started to slow for traffic and depressed the brake, and felt no braking. The contact had to depress the brake pedal to the floorboard. The contact stated that the brake warning light was illuminated. The contact was able to safely stop and drove the vehicle to his residence. The contact had taken the vehicle to a local dealer who diagnosed that there was a fractured parking brake spring. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure…
Service Brakes · at 201,000 miles · reported Mar 31, 2020
As vehicle comes to a slow stop the brakes feel as if the release and still roll also when pulling into a driveway or parking spot this has happed often.
Structure · at 195,000 miles · reported Jan 9, 2020
I swerved to miss a deer and I hit a tree running 47 MPH and my air bags didn't deploy and no one can tell me why. My husband and I were very lucky but why didn't the air bags deploy? My husband was out of work for 5 months due to torn ligaments in his shoulders and still has to have surgery.
Service Brakes · at 192,219 miles · reported Mar 14, 2016
Two years ago I had a sever accident that cause me to hit another car and spin around. The gmc dealer said the cause was rusted out brake lines. Today it happened, but I was luck enough to be just pulling into my parking spot when it happened. The brake line must have rusted out again because I pumped the brake and noticed it coming out of the left rear line. This is very dangerous because it will likely only happen when you are in an emergency situation. There is no pre warning. It will just happen. Perhaps they are making the brake lines out of thinner material because we have many vehicles…
Service Brakes · at 88,000 miles · reported Feb 16, 2016
I drove approx. 30 miles to my destination without any trouble. I spent about 2 hours there then started my 2002 yukon xl to head back home. Upon moving the vehicle I realized I had very limited breaking power. The brake pedal went right to the floor. I dread thinking about what could have happened if I was on the interstate heading home. My mechanic said the brake line failed causing the rear brakes to lose all stopping power. He said he has seen several cases of this same problem on early 2000's gmc trucks and SUV's. I researched this issue and found many of the same complaints online. Gmc…

Other GMC Yukon XL years

202620252024202320222021202020192018201720162015201420132012201120102009200820072006200520042003200220012000

Compare all GMC Yukon XL years · All GMC models

Frequently asked questions

Does the 2002 GMC Yukon XL have any recalls?

Yes — NHTSA lists 1 recall for the 2002 GMC Yukon XL: 05V-379 (service brakes, hydraulic). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2002 GMC Yukon XL?

Owners report service brakes, hydraulic problems most often (19 reports), followed by steering (13). The typical mileage when problems were reported is about 64,000 miles.

Are GMC recall repairs free?

Yes. Safety recall repairs are free at authorized GMC dealers, whether you are the first owner or bought the car used.