2002 Suzuki XL-7 recalls and problems

The 2002 Suzuki XL-7 has 2 safety recalls and 35 owner complaints filed with NHTSA. Recall repairs are free at any Suzuki dealer.

Recalls

Complaints

Crashes / fires

5 / 1

Injuries / deaths

2 / 0

Recalls may cover only some 2002 Suzuki XL-7 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2002 Suzuki XL-7 recalls

Recall 05V-452: Service Brakes, Hydraulic

Reported Oct 5, 2005 · 801 vehicles affected · AMERICAN SUZUKI MOTOR CORP.

Problem: On certain sport utility vehicles equipped with 16-inch wheels, the front brake discs may break under severe driving conditions. The breakage can occur in conditions where the vehicle is driven on a regular basis on extremely steep paved down-slopes while continuously applying the brakes.

Risk: The front brakes may become inoperative and the vehicle may pull to one side. This could result in a crash without prior warning.

Fix: Dealers will replace the front brake discs on these vehicles. The recall began on november 10, 2005. These vehicles are located on st. Thomas island (Virgin islands). Owners may contact suzuki del caribe at 787-622-0600.

Recall 03V-512: Vehicle Speed Control

Reported Dec 5, 2003 · 196,876 vehicles affected · AMERICAN SUZUKI MOTOR CORP.

Problem: On certain sport utility vehicles, the accelerator cable casing cap that is attached to the vehicle firewall can crack due to extended exposure to forces from the accelerator cable and insufficient long-term durability of the plastic casing cap. If the casing cap becomes cracked, movement of the inner accelerator cable through the cap can cause the inner accelerator cable to become frayed.

Risk: If the inner accelerator cable becomes frayed, it can stick during vehicle operation. In the case where an accelerator cable sticks, the driver could have difficulty controlling vehicle speed, which could result in a crash.

Fix: Dealers will replace the accelerator cable, which includes the plastic casing cap. Owner notification began on january 5, 2004. Owners should contact suzuki at 1-800-934-0934.

2002 Suzuki XL-7 problems reported by owners

Problem area	Reports
Vehicle Speed Control	7
Engine and Engine Cooling	7
Power Train	5
Service Brakes, Hydraulic	4
Steering	4
Suspension	2
Electrical System	2
Tires	2
Fuel System, Gasoline	2
Equipment	2
Air Bags	1
Visibility	1

Most reported parts

Vehicle Speed Control › Accelerator Pedal — 3
Equipment › Appliance › Air Conditioner — 2
Suspension › Front — 1
Power Train › Automatic Transmission › Lever and Linkage › Floor Shift — 1
Electrical System › Ignition › Switch — 1
Service Brakes, Hydraulic › Foundation Components › Disc › Pads — 1
Vehicle Speed Control › Cables — 1
Engine and Engine Cooling › Engine — 1

Typical mileage at the time of the problem: 48,000 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2002 Suzuki XL-7 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Steering · at 115,420 miles · reported Oct 17, 2014

This 2002 suzuki xl7 limited started to have touchy steering at 55 MPH and up. It is so sensitive that it can even change lanes. When the steering acts up the whole vehicle vibrates. I had new tires and alignment and checked for any slack in anything under the vehicle and it checked out good. I have checked on the internet and found that several people have had the same problem. Some of the people spent hundreds of dollars and still have the same problem. I think that it is dangerous to drive and other people need to know about the problem.

Structure · at 80,000 miles · reported Oct 11, 2012

Ac compressor went out twice in my 2002 suzuki xl-7. Once in august 2009 and again in may 2012. I had to have it replaced twice because it was a pretty hot summer. It assume if the car last another few years, I will have to replace it again. How annoying! Also, after the summer months, during the winter months when I need to turn on the heat, the service engine light comes on. I got this tested and it had to do with the AC compressor. This makes sense because the xl-7 compressor is dual. It's runs AC and heat. Power steering has been leaking for the past year. I would add power steering fluid…

Suspension · at 137,000 miles · reported May 23, 2012

The contact owns a 2002 suzuki xl7. The contact stated that the vehicle would pull to the right abnormally when driving at any speed. The vehicle was taken to a local mechanic and the failure was located as the front cross member being broken due to defective material. The failure caused the engine to lean to the right. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 137,000 and the current mileage was 141,000.

Vehicle Speed Control · reported Oct 12, 2011

The contact owns a 2002 suzuki xl7. While driving approximately 55 MPH, the accelerator pedal was depressed and the vehicle abnormally accelerated. The brakes were engaged and the vehicle slowed down with a loud grinding noise. The manufacturer was notified of the problem and they advised the vehicle be taken to an authorized dealer for diagnosis. The vehicle was taken to an authorized dealer who was unable to duplicate problem. The approximate failure mileage was unavailable.

Service Brakes, Hydraulic · at 105,000 miles · reported Jan 28, 2011

Condensation from vehicles air conditioning drips onto the insulation around brake line that is supposed to protect brake line from exhaust manifold heat. Living in texas the vehicle rarely is turned on without the air conditioning. The continued saturation, drying and vibration of normal day to day use caused a leak in one of the two brake lines leading to the rear of the vehicle. This was discovered after owner reported spongy feeling and loss of brake holding strength while in stopped position. Upon further inspection it was noticed both brake lines behind protective insulation has sever…

Other Suzuki XL-7 years

2006 2005 2004 200320022001

Compare all Suzuki XL-7 years · All Suzuki models

Frequently asked questions

Does the 2002 Suzuki XL-7 have any recalls?

Yes — NHTSA lists 2 recalls for the 2002 Suzuki XL-7: 05V-452 (service brakes, hydraulic), 03V-512 (vehicle speed control). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2002 Suzuki XL-7?

Owners report vehicle speed control problems most often (7 reports), followed by engine and engine cooling (7). The typical mileage when problems were reported is about 48,000 miles.

Are Suzuki recall repairs free?

Yes. Safety recall repairs are free at authorized Suzuki dealers, whether you are the first owner or bought the car used.