2004 Suzuki XL-7 recalls and problems

The 2004 Suzuki XL-7 has 2 safety recalls and 45 owner complaints filed with NHTSA. Recall repairs are free at any Suzuki dealer.

Recalls

Complaints

Crashes / fires

6 / 0

Injuries / deaths

4 / 1

Recalls may cover only some 2004 Suzuki XL-7 vehicles. Check your VIN at NHTSA ↗ to see open recalls for your exact car.

2004 Suzuki XL-7 recalls

Recall 05V-452: Service Brakes, Hydraulic

Reported Oct 5, 2005 · 801 vehicles affected · AMERICAN SUZUKI MOTOR CORP.

Problem: On certain sport utility vehicles equipped with 16-inch wheels, the front brake discs may break under severe driving conditions. The breakage can occur in conditions where the vehicle is driven on a regular basis on extremely steep paved down-slopes while continuously applying the brakes.

Risk: The front brakes may become inoperative and the vehicle may pull to one side. This could result in a crash without prior warning.

Fix: Dealers will replace the front brake discs on these vehicles. The recall began on november 10, 2005. These vehicles are located on st. Thomas island (Virgin islands). Owners may contact suzuki del caribe at 787-622-0600.

Recall 03V-512: Vehicle Speed Control

Reported Dec 5, 2003 · 196,876 vehicles affected · AMERICAN SUZUKI MOTOR CORP.

Problem: On certain sport utility vehicles, the accelerator cable casing cap that is attached to the vehicle firewall can crack due to extended exposure to forces from the accelerator cable and insufficient long-term durability of the plastic casing cap. If the casing cap becomes cracked, movement of the inner accelerator cable through the cap can cause the inner accelerator cable to become frayed.

Risk: If the inner accelerator cable becomes frayed, it can stick during vehicle operation. In the case where an accelerator cable sticks, the driver could have difficulty controlling vehicle speed, which could result in a crash.

Fix: Dealers will replace the accelerator cable, which includes the plastic casing cap. Owner notification began on january 5, 2004. Owners should contact suzuki at 1-800-934-0934.

2004 Suzuki XL-7 problems reported by owners

Problem area	Reports
Air Bags	28
Service Brakes, Hydraulic	8
Vehicle Speed Control	6
Electrical System	4
Seat Belts	3
Structure	2
Seats	2
Power Train	2
Engine and Engine Cooling	1
Latches/Locks/Linkages	1
Interior Lighting	1
Exterior Lighting	1

Most reported parts

Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip — 5
Structure › Body — 1
Engine and Engine Cooling › Engine — 1
Air Bags › Frontal › Sensor/Control Module — 1
Air Bags › Frontal — 1
Service Brakes, Hydraulic › Foundation Components › Master Cylinder — 1
Latches/Locks/Linkages › Doors › Latch — 1
Power Train › Driveline › Differential Unit — 1

Typical mileage at the time of the problem: 55,400 miles (median of owner reports).

Problems that are not covered by a recall are paid repairs; labor rates follow local mechanic pay — see what auto mechanics earn in each state.

Recent 2004 Suzuki XL-7 complaints

Owner reports filed with NHTSA, as written (personal details removed). Complaints are not verified by NHTSA.

Service Brakes · reported Aug 12, 2017

Bought this vehicle from original owner. After noticing some issues & looking back over carfax, repair report, & recalls online, I called suzuki. Gave the VIN# and was told a recall was done in 2004 by dealer. When asked about the other recalls, she said there was no other recalls. All paperwork I have has no indications of the recall being done. I see 3 recalls on this site as well. What should I do or who should I contact?

Vehicle Speed Control · at 175,000 miles · reported Mar 23, 2017

Recall 03v51200 affected part of the 2004 xl7 but not those produced after 6/13/2003. The latter vehicles have the same problem with the accelerater cable sticking. On march 18, 2017 my wife's cable got stuck and her vehicle almost rear ended a diesel truck on highway 99 south in sacramento, ca. If she hadn't put the vehicle in neutral she wouldn't have stopped so I looked recall notices and found the above stated recall. Just to find out that her vehicle suffered from the same affliction as the vehicles that were recalled but wasnt included. This is so dangerous and I feel all the vehicles…

Air Bags · at 80,000 miles · reported Sep 10, 2014

Going on a small trip, and my passenger, a rather large man, sat in pass front seat, and the airbag light came on the dashboard, and the clock started flashing. Brought to braintree toyota, nearest dealership that worked on suzukis, and they were able to recalibrate under pass seat, reset, and all worked until a few months later, when the same man sat in the pass seat, and again, the airbag light came on and the clock flashed, and has been ever since. I have been living with this problem now for about 3-4 years and was told that the parts to replace would be sensors at a cost of about 1500.00…

Air Bags · at 105,000 miles · reported Mar 15, 2014

After a snow storm we got into our vehicle and started it to warm it up. The airbag light wouldn't go off and the display on the stereo flashed continuously. From this point on, these displays continue to stay on at all times. After checking with the deal and suzuki, we were told that the passenger side air bag sensor is broken. It can happen from sitting things on the seat other than a person, a heavy person on the seat, normal every day use, and finally the cold. I'm told the consequence of this is that the passenger air bag is off and will remain off from that point on. The only fix is to…

Air Bags · at 52,000 miles · reported Oct 28, 2013

The contact owns a 2004 suzuki xl-7. The contact was driving 55 MPH and noticed that the passenger's side air bag warning light was illuminated with the passenger seat unoccupied. The vehicle was not taken for diagnosis. The manufacturer was not made aware of the issue. The approximate failure mileage was 52,000. Updated 01/07/14

Other Suzuki XL-7 years

2006 200520042003 2002 2001

Compare all Suzuki XL-7 years · All Suzuki models

Frequently asked questions

Does the 2004 Suzuki XL-7 have any recalls?

Yes — NHTSA lists 2 recalls for the 2004 Suzuki XL-7: 05V-452 (service brakes, hydraulic), 03V-512 (vehicle speed control). Not every vehicle is affected, so check your VIN at nhtsa.gov/recalls.

What is the most common problem with the 2004 Suzuki XL-7?

Owners report air bags problems most often (28 reports), followed by service brakes, hydraulic (8). The typical mileage when problems were reported is about 55,400 miles.

Are Suzuki recall repairs free?

Yes. Safety recall repairs are free at authorized Suzuki dealers, whether you are the first owner or bought the car used.